Back to School Ideas Cardboard Record Album Cover Crafts: Upcycled Folder from a Cardboard Record Album Cover

Published on October 3rd, 2016 | by Julie Finn

3

How to Make an Upcycled Folder from a Cardboard Record Album Cover

You’re going to have the coolest school supplies on the planet when you make yourself an upcycled folder from a cardboard record album cover.

Here's how to make a folder from the cover to a record that's no longer playable.

Here’s how to make a folder from the cover to a record that’s no longer playable.

Cardboard record album covers are perfect for this project–they’re a little sturdier than your regular dime a dozen cardstock folders (which is a good thing!), but still light and easy to carry, and their prominent graphics both recall the look of your favorite themed folders and are unique to your own old-school interests. Seriously, where else on the planet am I going to find a Simon and Garfunkel folder for myself?

Tip: To find cardboard record album covers to upcycle, check out yard sales and thrift stores. People barely know how to properly store records anymore, which means that a lot of the ones that you can pick up on the cheap have been mistreated and are now completely unplayable. Unplayable records are records ripe for upcycling!

Here's how to make a folder from the cover to a record that's no longer playable.

How to Make a Folder from an Album Cover

You will need:

cardboard record album cover. You’ll need one entire record album cover, as well as one additional piece of cardboard of the same dimensions. Two record sets will provide the necessary cardboard, or you can utilize part of another record album cover.

x-acto knife and self-healing cutting knife. Fair warning: I have a post about craft knife safety coming up in a few days, because while cutting the cardboard to make one of these folders, I sliced a gigantic piece of flesh almost completely off of my index finger. I then proceeded to half pass out in the middle of the floor, bleeding profusely, while my two children hovered over me, horrified, and repeatedly asked me what to do.

It’s important to make memories with your children, My Friends!

duct tape. Duct tape isn’t an eco-friendly craft supply, but it IS the best supply for the job here. You’re also not going to be using a ton of it, and the folders that you make are sturdy enough that they should last for a super long time, so I’m comfortable with it. If you’re not, play around with perhaps stitching or lacing up your folders, and then tell me all about it in the Comments below!

Upcycled Folder from a Cardboard Record Album Cover

1. Measure and cut your cardboard record album cover. For this folder, you will be using both the front and back of one cardboard record album cover, keeping them attached on the left side to form the folder’s natural fold.

The height of the record album cover, 12″, is perfect for a folder. To get the correct length, 9.5″, cut the excess 2.5″ away from the right side of the cover.

Watch your fingers!!!

Slit open the top and bottom of the record album cover, leaving the left side attached.

2. Measure and cut the upcycled folder pockets. From a second piece of cardboard, measure and cut two rectangles with the dimensions “9.25 x 5”. Notice that the length of the cardboard is slightly less than that of each folder half–this will decrease bulk at the fold. The height of each pocket is up to your discretion, although 4″-5″ looks proportionate and will do a good job holding your papers.

3. Tape the hinge of the upcycled folder. Measure out a piece of duct tape that’s a little longer than the height of the folder, then cut it in half lengthwise–you’ll have the easiest time if you use duct tape scissors (I own this pair). Use  one of the halves to cover and strengthen the folder’s hinge.

Upcycled Folder from a Cardboard Record Album Cover

After you’ve folded the duct tape to cover both sides of the hinge, trim off the excess at each end.

4. Place and tape the pockets. Turn the folder over and place the cardboard pockets on each side, lined up with both the bottom and outside edges. Use the second half of duct tape to cover the inside hinge, catching both cardboard pockets.

Upcycled Folder from a Cardboard Record Album Cover

Overlap or trim off any excess tape at each end.

5. Tape all the other edges. You can now cover the perimeter of the folder with duct tape, again measuring out the correct length for a side and cutting it into two lengthwise.

Upcycled Folder from a Cardboard Record Album Cover

Fold each piece of tape under to cover both the outside and inside edges of the folder, and don’t forget to make sure that the tape catches the edges of the cardboard pockets, too.

Trim excess tape after you’ve taped each side:

Upcycled Folder from a Cardboard Record Album Cover

These folders really are SUPER sturdy, and will stand up well to being tossed into a backpack and used all year.

And next school year, you can use them again!

Keep up with the latest in the world of green crafts by signing up for our free newsletter. CLICK HERE to sign up!


Tags: , , , , , , , , , , , ,


About the Author

I'm a writer, crafter, Zombie Preparedness Planner, and homeschooling momma of two kids who will hopefully someday transition into using their genius for good, not the evil machinations and mess-making in which they currently indulge. I'm interested in recycling and nature crafts, food security, STEM education, and the DIY lifestyle, however it's manifested--making myself some underwear out of T-shirts? Done it. Teaching myself guitar? Doing it right now. Visit my blog Craft Knife for a peek at our very weird handmade homeschool life; my etsy shop Pumpkin+Bear for a truly odd number of rainbow-themed beeswax pretties; and my for links to articles about poverty, educational politics, and this famous cat who lives in my neighborhood.



3 Responses to How to Make an Upcycled Folder from a Cardboard Record Album Cover

  1. wasnowcreations says:

    I love this idea — there are SO many record albums with funky covers waiting to be upcycled. A few years ago, I turned some holiday albums into gift boxes. Info here: http://creativeupcycling.blogspot.com/2011/12/making-gift-box-out-of-vintage-holiday.html

  2. Wow! That is a great idea! I have so many old album covers that I could do this to!

  3. BCS Plumber says:

    I could really use these for school!

Leave a Reply

Back to Top ↑
  • Advertisement



  • Let’s Connect!

  • Popular Posts + Pages


    The Crafting a Green World guide to choosing green art and craft supplies.

    Green Crafts for Kids

    DIY Ideas for Home

    Do you love toilet paper roll crafts as much as we do? Today we’re sharing 50 projects that you need to see!

    We’ve rounded up 25 incredible DIY crafts and activities that will make you rethink the average disk. Click through each link below and be inspired!

  • Back to Basics Ebook

    We are thrilled to have a project in Jen Gale’s guide to mending. Get your copy here!


Shares